The beginning of July, some places still hot climate, scorching sun, we are still in a hurry how Qushu when the sun has already ushered in some places several days of heavy rain, many places have even begun to make preparations for flood control. Rainy season came, loader work is still orderly conduct, days of rain loader work also brings many problems, the following is said on rainy days loader work should pay attention to.
Very well, do not spray armor Friends!
Better site such as ore, road is not very good, in addition to the basic pond stone pavement is the dirt road, after heavy rain the potholed pavement red mud accumulation in many places, the road became very slippery, even excavator becomes difficult, but If you need emergency flood assistance loader out, it would have on, no way to do this trip on this. But we must pay attention to safety, especially when working in the rain.
Rain must pay attention to the road conditions of work, especially in some places particularly thick mud, mud after heavy rain drenched wet, slippery, work in these areas must pay attention to the case of the environment, always observe, When shoveling material can use a small throttle work, safe number, do not worry, because slippery road loader bucket insert the material quickly if the operator can easily result in improper or wheel loaders skid, sometimes the more shovel does not go you increase the throttle a wheel skid more serious, not only shovel dissatisfaction, but also damage the machine, or more if necessary, to play a reverse gear, shovel once more, to avoid unnecessary damage to the tires, if it is to work on the concrete floor Fortunately, if it is not the same dirt road, in some places the road full of mud, the following may be buried in a lot of sharp stones, long time if the tire slip, rub the stone could easily draw a road tire scars, then wear a few months will be because of your move and click on a little worn out, it is much to lose. When the open-air park pay attention to check the fuel tank and hydraulic tank lid is tightly closed to avoid the rain infiltrated the tank to cause unnecessary trouble.
Loader installation necessary is the need for snow chains, in order to increase the safety factor, anti-skid chains should be installed in advance, do not start the installation only if you encounter extreme environments, such mounting insecurity hurried too much trouble, if it is a special case When installing warning signs must be placed at the front and rear loaders. Do not install in the tire pressure would not be enough snow chains, followed by the major chains are also different size wheels and wheel size to select the size to match the width of tire chains, snow chains after installation should pay attention to the loader with speed not too fast, and note Avoid sudden acceleration or deceleration of the tire chain damage.
Loader park is particularly important during the rainy season, able to do the last stop to the garage, try to avoid excessive parked in a humid environment for indoor storage, rustproof operation is very important for a long time each month to launch a machine should be parked and driving, make battery charging. Long-term storage should be dry when the machine oil on the piston rod, the components greased. The best part of the engine rainy parking garage toward the inside, there are some careless driver put the car into the garage that you can, and just did not pay attention to the engine part eaves below about rain splashed red on the engine, that scene ...... I witnessed, so do not be careless parking.
Rain also want to examine the air filter cartridge loader, to avoid the rain to enter, make a paper filter clogging damage deterioration, the timely replacement of maintenance. Also note that the engine dipstick seal wear, avoid the wear causes rainwater seeped into the oil inside the oil filler have to check, open-air park can be put in a plastic bag, if necessary, is foolproof.
Check the starter each thread usage, to see if there are loose or corroded, identify problems in time to avoid moisture starter affect their life. Check generator usage, each line connectors to avoid moisture affect the power effect.
Rainy season work is still one of the most common problem is still shaking afford a bucket of slime bucket material handling equipment should take full advantage of the work of the stopper and to ensure maximum tilt angle of the bucket, when unloading to unload and clean shovel The bonding material inside the bucket, the bucket can be reciprocally joystick operation, the bucket of the bucket hitting the stopper in the bonding material due to vibration and fall off, but not too much of a continuous crashing stopper or easy resulting in manipulation of soft fracture, bucket cylinder damaged.
Rainy season should pay attention to wind loader work, anti-collapse, moisture, anti-skid. Rain vigilant work, night work should be maintained around the loader headlights, work lights, dome light, dashboard lights, wipers and other work, to ensure safety.
|
